In a line:
Didn’t miss a beat over a month; no one was more surprised than me.
• At £4000, with the stock equipment it’s a bargain
• Low, 800mm seat – at last a travel bike not limited to tall people
• Enfield build quality stood up to it
• Efi motor pulled smoothly up to 3000m (nearly 10,000′)
• Michelin Anakee Wilds (run tubeless) – great do-it-all tyres
• Low CoG and 21-″ front make it agile on the dirt
• Rear YSS shock showed up the rather harsh forks
• Yes it’s 190kg, but road and trail, it carries it well
• Subframe easily sturdy enough for RTW load carrying
• Economy went up and up: averaged 78 mpg (65 US; 27.6kpl; 3.62L/100k)
• 400km range from the 15-litre tank – about 250 miles
• Weak front brake on the road (fitting sintered pads is a fix)
• As a result, front ABS is a bit docile
• Stock seat foam way too mushy for my bulk
• Tubliss core failed on the front; replaced with inner tube
• Centre stand hangs low – but can be raised
• Valves need checking every 3000 miles (according to manual)
• Small digit dash data hard to read at a glance
• Compass always out
• Head bearings notchy at 4000 miles, despite regressing @ 1200 (replaced on warranty @ 5000)
Following a test ride, I bought my Himalayan just under 1000 miles old. Following the make-over detailed here (summarised in the image below) I picked it up in southern Spain with 1300 miles on the clock. So, like many of my crudely adapted project bikes, I’d barely ridden the thing or tested the modifications. With a Royal Enfield this did feel a bit more of a gamble than usual and, on collection near Malaga I was all prepared for the worst.
Far from it. The Him started on the button, ticked-over like a diesel and after the ferry crossing and sailing the usual gale down the Atlantic coast, I arrived at a cushy hilltop lodge out of Asilah feeling moderately hopeful, while still braced for a kick in the nuts somewhere down the road.
Riding an untried, near-new machine, saddled with Enfield’s possibly outdated reputation led to stressful days, waiting for something to play up, either with the bike or with my mods. But riding my first piste: the lovely Assif Melloul gorge route out of Anergui inspired confidence. This was a great trail bike!
Engine and transmission
Much is made of the 410LS’s meagre 24hp because we’re so used to bikes delivering over 100hp per litre. Don’t forget Honda’s CRF450L makes about the same. It’s when you combine it with the strapping 190-kilo wet weight you’d think it can’t possibly work. Yet it does – and in a way that you won’t find on a similar powered and much lighter 250 trail bike like the WR250R, KLX250S or CRF250L which I’ve also used in recent years, as well as a 310GS. I prefer riding the REH to all of them.
It must be down to the way the long-stroke, low compression, two-valve motor delivers it’s modest power, like something from the apogee of Brit biking half a century ago, but without a millstone for a flywheel it revs more freely. The Himalayan may have the power of a CRF250L, but it has the torque of an XR400: 32Nm at 4250rpm (1150 lower than the XR). Combined with counter balancer and unexpected refinement, despite wide gearing it’s a very satisfying bike to ride. It won’t hurl you from bend to bend, it just chugs along steadily but without the sensation that you’re missing out or grossly under-powered. The key is to maintain smooth momentum which is very much the riding style I aspire to. It’s an easy bike to enjoy on the empty roads and even emptier trails of southern Morocco. Duelling with congested traffic or tackling busy alpine passes may not be such fun.
Until the end of my trip – by which time the valves were technically well overdue for adjustment – it started on the button without the ‘choke’, ticked over once warmed up (probably needs adjustment too) and fuelled cleanly up to 5000rpm and nearly 10,000 feet (3000m). A lot of it must be down to accepting the Himalayan for what it is, but there was never a moment on my ride when I thought ‘FFS! I wish this thing had more poke’. I tried some super grade fuel in Morocco but didn’t notice the difference that some claim (I know in the US fuel octane varies widely). However, once back on Spanish fuel, it did seem faster and smoother, or maybe I was just rushing for the finish line.
One thing the Trail Tech temperature sensor did highlight was how hot the engine runs – up to 240°C at higher revs with a load on. Note I say ‘hot’, not over-heating. On my bike it’s reading from the spark plug, about as hot as it gets in there. Running down hill it might drop to 160°C or so. Either way, especially with an air-cooled motor, it’s good to know how hard the engine is working an when it may be time to back off.
Oil consumption was zero up to a pre-emptive oil change at 3000 miles. Straight 50W Moroccan was all they had (a bit thicker; better for hot weather) and I had the feeling consumption increased briefly after that, maybe 200ml in 2000 miles, but then it stopped.
The gearbox is a lot less clunky than some. Originally, I thought first gear would be too tall off road (a common complaint) but, helped by the low-down torque, it’s well matched to the Himalayan’s modest trail biking abilities which are governed mainly by its weight. One time in deep soft sand, the gearing was too tall to move the bike forward – the chain jumped on the front sprocket instead (see below). You can change up without, but I can’t break the habit of using the clutch when changing gear.
The chain had a hard time in Morocco: conditions too gritty to lube most of the time. On longer road stretches I hand-lubed with a toothbrush from small bottle of Tutoro oil. As a result I adjusted it three times in 4000 miles – more than normal, even for a stock chain. Again, you have to assume the stock chain was chosen for its price, not quality, but with a bit more care and lube it should last 8000 miles.
Normally the suspension is where a budget bike shows its limits once pushed on rough roads, with heavy loads, or on the dirt. Plus I tend to leave my tyres at road pressures unless absolutely necessary, so as a result off-road the my suspension can feel a little harsher than it could be.
On the rear there’s only preload adjustment and nothing on the front, but the Himalayan surprised me with firm suspension. Before I realised this I’d fitted some inexpensive fork preload caps, (set at zero), and a YSS shock that had 1cm of length adjustment and 35 clicks of rebound damping. I had the YSS fitted on the settings out of the box (more here) which worked fine once loaded up and on the dirt. At one point in Morocco I screwed the rebound in 4 clicks (more rebound?) but can’t say I noticed any difference.
Overall, I suspect the stock shock (inset above) would have been OK, but you have to assume the YSS must be an improvement because there’s more adjustment and it’s red. It certainly felt better than a twice-as-expensive Wilbers on the XSR last year. Over the trip it loosened up a bit and bottomed out maybe once.
If anything the front forks are now shown up by the YSS. YSS do offer a fork kit but in the UK it’s £330 (though it seems you can buy springs plus the emulators for half that). Bottom line: no great need to meddle with the stock suspension for normal riding.
It seems that even at a 1300 miles the air-cooled REH was still running in. As I added the miles the economy improved, eventually averaging 78.7mpg (27.8kpl; 65US). With the 15-litre tank that’s a potential range of just over 400km. Riding with some 310GSs for a week, my mpg was near identical to the more powerful and lighter BMWs. The gauge on the tank is pessimistic and the warning light plus a trip reset comes on with a good 100km left. Hot, cold, high, low the fueling itself was glitch-free. Fuel consumption data here.
Thanks to a counter-balanced and non-ginormous capacity, the REH is very smooth for a single. I did feel some tingling in my right hand after hours at the bars which could have been from over-gripping a heavy throttle. I’d have used my throttle handrest had I remembered it.
One of the best things about the Himalayan is the low seat of 800mm or 31.5 inches. At 6′ 1″, it’s actually a bit too low for me, especially once my mass sinks down through the soft foam, but at last there’s a travel bike which isn’t limited to tall people, while still having useful ground clearance.
I needed more height with firmer foam, inexpensively achieved with a couple of 20mm slabs under a Cool Cover. It enabled 500-km days with few stops, but on rough tracks still gave soreness, probably because I wasn’t standing up or letting the tyres down enough. I also thought the seat could do with levelling out to stop me sliding forward on the aerated Cool Cover.
My seat bodge was not a night-and-day transformation, but by the end of my trip it didn’t cause any discomfort over long days on the road. I’m less convinced now that I need to improve it some more.
The 50mm bar risers managed to not snag the screen on full lock and nearly reduced my stooping when standing up – another inch would have done it. I might have cured that stoop by removing the footrest rubbers, but to be honest I liked the comfort when standing (in ordinary slip-on boots). Otherwise, for wet conditions, consider fitting wider footrests if you’re off-roading. I hear that DR650 pegs nearly fit.
Some say it will clock 80 but I set myself a self-imposed cruising limit of around 65mph (where possible). At this speed the screen did a pretty good job, even with my wind-catching Bell Moto III helmet. Others claim the mirrors create turbulence and are better moved or changed. I suppose this is possible but it’s a new one on me. Let’s face it: it’s a motorbike out in the wind, not a space capsule. Some turbulence will be evident.
On the dirt
The Him took to the dirt so naturally, I didn’t even notice it at first. The key attributes must be the Michelin tyres, low seat and firm suspension. The 21-inch front wheel must help too, as does the torquey motor, getting round the wide gearing. And the otherwise ordinary brakes are just right on the dirt.
The Him is a plodder, but then so am I. You won’t be pulling wheelies, launching of jumps or bouncing off berms. For that the bike is just too heavy and low-powered. It’s a travel bike, not a dirt bike and in all the miles I never ever had a sketchy moment on the dirt, nor wished the bike was something else.
I reached the Himalayan’s limit in the sandy gorge on Route MW6/7 in Western Sahara – same place I’d struggled with the WR two years earlier. This time I traced a better route along the valley but the flooded waterhole was now a dry mass of tracks in which the Himalayan would bog down for sure. I aired down, pushed around the side in first but stopped once I the chain jumped on the front sprocket from the strain: the torque had got the better of the weight and tall gearing. The Himalayan doesn’t have the agility or power to handle deep soft sand – for that you want an unloaded KTM 450.
Durability and problems
It’s a short list. Apart from what’s below, nothing broke or even came loose, but I’ve not seen the bike since I left it at Malaga. A closer inspection may reveal more.
• Head bearings got notchy by 4000 miles, despite regreasing
• Chain needed adjustment every 1000 miles
• Exhaust guards dented
• Tubliss core leaked around valve stem, then packed up
• Michelin TPMS packed up – twice
The Himalayan is a rare type of all-road travel bike, one that not only looks fit for the job as many adv bikes do – but one that’s actually equipped for it and performs well, too. You might not think 24hp and 190 kilos (420 lbs) adds up, and for some it won’t. But for your £4000 or $4500 you get a lot of kit that’s no found on similar bikes. Don’t dismiss it as a shoddily assembled Asian cheapie or anything to do with the Bullets. The bike has caught on and in western markets the demand for the BS4 has outstripped importers’ expectations. If you’re curious like I was, try one. You might also be surprised.
Pingback: Royal Enfield Himalayan Miles per Gallon: Unleashing Mystery
Purchased a new one in 2018.
Been a great bike and yes a joy to ride 3years and 45000 ks on still love it.
LikeLiked by 1 person
I took out a Ducati V4, Africa Twin, Indian Chief etc at ABR festival last year, but the most fun was on the Himalayan. Not fast, but just so much fun, and so easy off road.
LikeLiked by 1 person
Chris, you mention that the center stand can be raised so that it’s not dragging on things. How is this done? Is there a kit, or some grinding, or….?
Hi Carl, iirc there is a little push-fit rubber peg on the top side of one center stand leg – maybe both – which stops it from banging against the underside of the chassis when sprung up. It ought to be obvious with the stand down. Pull out the peg or replace it with something less thick and the stand will raise higher = more clearance. Hope that helps
Great review, just turned 13000 miles on my Himalayan and still love it. Take me everywhere with full camp gear and never complains.
That little engine just keeps pulling.
LikeLiked by 1 person
Great and realistic review. I have downsized from a BMW F800gs and an SWM RS650R and wondered if I had made a mistake. I couldn,t have been more wrong. It is a great little bike with cheap purchase price,cheap and readily available spares ,a very relaxed riding style etc. Being over six feet tall the seat had to go in favour of a seat concepts tall seat which is broader,higher and more supportive. The screen produces a lot of turbulence at head height but I cut the screen height down and it is much better. I love my bike and it is a keeper.
Great to hear you get on with your Him, Steve. Better too low a seat than too high. Him proves it can be done.
I have fond memories of mine in Morocco (but I did van it across Spain).
What was the SWM RS650R like?
Hi, Steve. Thinking about the same downsizing here: From F800GS to Himalayan, mainly for height and weight. Can you elaborate a bit more on the swap? What is better, what are you missing from the beemer, etc., etc.
Thank’s a bunch.
Thank you for your ideas!
Nice real world review. I think it is great RE found a market that all the other manufactures are ignoring. A good low cost, not cheap, capable motorcycle. Harkens back to Ted Simon’s world trip on a Triumph 500 back in the early 70’s.
steve in yorkshire enjoyed your review. i bought one last year and love riding this easy going real bike.i have two other bikes that cost a lot more than my REH but the bike i ride most is my himalayan,just retuned from NC500 the bike has done over 5000 miles and never missed a beat
I traded a Yamaha R6 in for one of these. Straight swap and have never looked back! I’m enjoying riding again. The simplicity of this machine is what makes it. The ‘no fear’ in going new places. This bike does and goes over practically everything. A smile a mile!
LikeLiked by 1 person
This review and so many others ,persuaded me back to biking after 40 years , I bought a Himalayan two weeks ago I’ve now ridden 500 miles in Mid Wales and haven’t wiped the grin off my face since I rode the demo bike , great review cheers
LikeLiked by 1 person
Nice review. Having been interested in something a little lighter than my 650 Revere but with a little more poke than my old XL250S, i had been looking at Mash 400, Honda CL400 and XL 350/400. The BS4 seems to be getting good feedback, and the electric foot is a luxury. Hoping to get one out for a test ride. Someone did suggest a Suzuki DL250 V-strom, that has the same hp and an even better power to weight ratio than the enfield, but not its torque ability, though equally good fuel consumption from reports. At least spares for the Enfield are likely to be around when those for Mash have all but gone…….
LikeLiked by 1 person
Thanks. Was just on mine yesterday after a month, caked in Moroccan dirt. Still amazed it started on the button and still think it’s a great machine. Definitely loads more torque than a 250 and just so easy to ride.
Great review Chris, think this bike is ideal for anyone who wants a cheap go anywhere machine and does’nt want to buy a 20 year old jap 600 that will no doubt need a grand throwing at it in replacing old and worn out parts. I think it can’t be too different to one of the original gs series bmw’s.
LikeLiked by 1 person
Lovely review and seemingly just what the market needs to cool down the fast and furious culture that is constantly promoted. A breath of fresh air..thanks.
LikeLiked by 1 person